After the beans are removed from their pods they're fermented, dried, roasted and cracked, separating the nibs (which contain an average of 54 percent COCOA BUTTER) from the shells. The nibs are ground to extract some of the COCOA BUTTER (a natural vegetable fat), leaving a thick, dark brown paste called chocolate liquor. Next, the chocolate liquor receives an initial refining. If additional cocoa butter is extracted from the chocolate liquor, the solid result is ground to produce unsweetened COCOA POWDER. If other ingredients are added (such as milk powder, sugar, etc.), the chocolate is refined again. The final step for most chocolate is conching, a process by which huge machines with rotating blades slowly blend the heated chocolate liquor, ridding it of residual moisture and volatile acids.

The only alcohol suitable for drinking is ethyl alcohol, a liquid produced by distilling the fermented juice of fruits or grains. Pure ethyl alcohol is clear, flammable and caustic. Water is therefore added to reduce its potency. In the United States, the average amount of alcohol in distilled spirits is about 40 percent (80 PROOF)A USDA study has disproved the theory that alcohol evaporates completely when heated. In truth, cooked food can retain from 5 to 85 percent of the original alcohol, depending on various factors such as how and at what temperature the food was heated, the cooking time and the alcohol source.

Alcohol has been used medicinally throughout recorded history; its medicinal properties are mentioned 191 times in the Old and New Testaments. Medical research suggests that alcohol can have a greater impact on heart disease than even these hard-won reductions in cholesterol levels or blood pressure. Only cessation of smoking is more effective.



source: fda & allrecipes.com

Sugar produced from cornstarch; comprised of glucose (dextrose), maltose and higher sugars; 70 percent to 80 percent solids

Sugar based sweeteners are those such as that developed from corn starch. The development of the various types of corn syrups, maltodextrins, and high-fructose corn syrup from corn starch sources could be called one of the greatest changes in the sugar and sweetener industry over several centuries. In the late 1800s it was found that corn starch could be hydrolyzed and a sugar formed. It was not until the 1970s that it became commercially a major product bringing about changes in the food industry. Over-reliance in the food industry and over-indulgence by consumers of these processed sugers, particularly high fructose corn syrup, has most likly contributed to obesity in many western countries.



These sweeteners are processed and refined using a series of separation, and grinding processes. Finally, the products are converted and fermented. From this processing a five classes of corn sweeteners are formed. This does not include the corn syrup conversion into high-fructose corn syrup.

Sweet Cream is the butterfat skimmed from milk.

"The term natural flavor or natural flavoring means the essential oil, oleoresin, essence or extractive, protein hydrolysate, distillate, or any product of roasting, heating or enzymolysis, which contains the flavoring constituents derived from a spice, fruit or fruit juice, vegetable or vegetable juice, edible yeast, herb, bark, bud, root, leaf or similar plant material, meat, seafood, poultry, eggs, dairy products, or fermentation products thereof, whose significant function in food is flavoring rather than nutritional."

The new labeling law effective in 2006, The Food Allergen Labeling and Consumer Protection Act (FALCPA), requires manufacturers to declare if one or more of the 8 major food allergens are contained in a natural flavoring. The top 8 major food allergens are defined as: milk, egg, fish, crustacean shellfish, tree nuts, wheat, peanuts and soybeans.

If you are managing food allergies other than the top 8 major food allergens, however, the new law will not be of assistance to you in identifying the sources in any natural flavoring stated on a label.

The FDA does not require companies to disclose ingredients of color or flavor additives so long as all the chemicals in them are considered by the agency to be GRAS ("generally recognized as safe") enabling companies to maintain secrecy of formulas. It also hides the fact that flavors often contain more ingredients than the foods to which they give taste.

A typical artificial strawberry flavor contains over 30 chemicals. According to manufacturer safety data sheets those chemicals cause eye irritation, corneal damage, eye burns, skin irritation, severe / permanent damage to digestive tract, gastrointestinal irritation, gastrointestinal tract burns, CNS depression, neurological effects, liver abnormalities, cardiac abnormalities, or other harm.

Natural flavor, according to the FDA, must be derived entirely from natural sources (herbs, spices, fruits, vegetables, beef, chicken, yeast, bark, roots, etc). Consumers prefer to see natural flavors on a label out of a belief they are more healthful.

Natural flavor is not necessarily more healthful or purer than an artificial flavor. Almond flavor when derived from natural sources may contain traces of hydrogen cyanide, a deadly poison. When derived by mixing oil of clove & amyl acetate, it does not. Natural flavors and artificial flavors are often manufactured at same chemical plants.

Flavor manufacturing may also involve biotechnology, using enzyme reactions, fermentation, & fungal and tissue cultures. Flavors created by these methods are considered natural flavors by the FDA.

In addition to flavor chemicals also think about genetic engineering of food, DNA or gene alteration, and medicines and hormones given to cows, cattle, hogs, and chickens. What affect does it have upon us? Some are suspected causes of cancer or other problems.

When a natural flavor or artificial flavor is added to a food or drink the resultant processed food is no longer natural & is potentially harmful.

Source: http://web.archive.org/web/20030608101921/www.cfsan.fda.gov/~dms/opa-bckg.html

Sugar cane is the source of sugar in all tropical and subtropical countries of the world. Estimates for 1966 and 1967 indicate world production of cane sugar was between 40 and 41 million tons. Production in the United States, excluding Puerto Rico, averaged 2,550,000 tons during those years - from 592,000 acres of cane in Hawaii, Florida and Louisiana. Sugar production in Puerto Rico averaged 850,000 tons for the two years.



Several species of Saccharum are found in Southeast Asia and neighboring islands, and from these cultivated cane probably originated. The sweet juice and crystallized sugar were known in China and India some 2500 years ago. Sugar cane reached the Mediterranean countries in the eighth century A.D., and reached the Americas in early colonial times.



The cane plant is a coarse growing member of the grass family with juice or sap high in sugar content. It is tender to cold, the tops being killed by temperatures a little below freezing. In continental United States, where freezing may occur during the winter, it is mainly planted in late summer or early fall and harvested a year later. In tropical countries it may be planted at almost any time of the year since the plant does not have a rest period. The season of active growth in continental United States is 7 to 8 months while in tropical countries growth is near continuous until harvest. This results in heavier yields of cane and sugar under tropical conditions. For example, yields of cane and sugar per acre in Hawaii, where the cane is grown for about 2 years before harvesting, are from 3 to 4 times vields in Louisiana and Florida from one season's growth.



Sugar cane plants are propagated by planting sections of the stem. The mature stems may vary from 4 to 12 feet or more ill height, and in commercial varieties are from 0.75 to 2 inches in diameter. The stem has joints or nodes as in other grasses. These range from 4 to 10 inches apart along the above-ground section of the stem. At each node a broad leaf rises which consists of a sheaf or base and the leaf blade. The sheaf is attached to the stem at the node and at that point entirely surrounds the stem with edges overlapping. The sheath from one node encircles the stem up to the next node above and may overlap the base of the leaf on the next higher node. The leaf blade is very long and narrow, varying in width from 1 to 3 inches and up to 5 feet or more in length. Also, at each node along the stem is a bud, protected under the leaf sheath. When stem sections are planted by laying them horizontally and covering with soil a new stem grows from the bud, and roots grow from the base of the new stem. The stem branches below ground so several may rise as a clump from the growth of the bud at a node.



In planting cane fields, mature cane stalks are cut into sections and laid horizontally in furrows. In continental United States sections with several nodes are laid while in tropical countries sections with 2 or 3 nodes are commonly used - since temperatures for growth are more favorable. Usually only one node on a stem piece develops. a new plant because of polarity along the stem piece.

Wheat flour is an excellent source of complex carbohydrates. Other than gluten flour, all types of wheat flour derive at least 80 percent of their calories from carbohydrates. Depending on the flour type, the percent of calories from protein ranges from 9 to 15 percent, except from gluten, which has a 45 percent protein content. Calories from fat are never more than 5 percent.



In addition, wheat flour provides from 3 g (cake flour) to 15 g (whole-wheat flour) of dietary fiber per 1-cup serving. Wheat flour contains B vitamins, calcium, folacin, iron, magnesium, phosphorus, potassium zinc and other trace elements, and minimal amounts of sodium.



Wheat is the most important cereal crop in the world and ubiquitous in our culture. Bread, pasta, bagels, crackers, cakes, muffins and other wheat containing products line our supermarket shelves and fill our grocery baskets. It is luck for us that this popular grain is available throughout the year.



Classes used in the United States are



Durum - Very hard, translucent, light colored grain used to make semolina flour for pasta.

Hard Red Spring - Hard, brownish, high protein wheat used for bread and hard baked goods.

Hard Red Winter - Hard, brownish, very high protein wheat used for bread, hard baked goods and as an adjunct in other flours to increase protein.

Soft Red Winter - Soft, brownish, medium protein wheat used for bread.

Hard White - Hard, light colored, opaque, chalky, medium protein wheat planted in dry, temperate areas. Used for bread and brewing

Soft White - Soft, light colored, very low protein wheat grown in temperate moist areas. Used for bread.

Hard wheats are harder to process and red wheats may need bleaching. Therefore, soft and white wheats usually command higher prices than hard and red wheats on the commodities market.



Wheat, in its natural unrefined state, features a host of important nutrients.



Therefore, to receive benefit from the wholesomeness of wheat it is important to choose wheat products made from whole wheat flour rather than those that are refined and stripped of their natural goodness.



The health benefits of wheat depend entirely on the form in which you eat it. These benefits will be few if you select wheat that has been processed into 60% extraction, bleached white flour. 60% extraction - the standard for most wheat products in the United States, including breads, noodles and pastas, baked goods like rolls or biscuits, and cookies - means that 40% of the original wheat grain was removed, and only 60% is left. Unfortunately, the 40% that gets removed includes the bran and the germ of the wheat grain - its most nutrient-rich parts. In the process of making 60% extraction flour, over half of the vitamin B1, B2, B3, E, folic acid, calcium, phosphorus, zinc, copper, iron, and fiber are lost.



Since 1941, laws in the United States have required "enrichment" of processed wheat flour with vitamins B1, B2, B3 and iron in response to the problems created by 60% extraction. Although not nearly as much of these B vitamins and iron are replaced as are removed from 60% extraction flour, "enriched" seems an odd word to describe this process. If you select 100% whole wheat products, however, the bran and the germ of the wheat will remain in your meals, and the health benefits will be impressive! Our food ranking qualified whole wheat (in its original non-enriched form) as a very good source of dietary fiber and manganese, and as a good source of magnesium.



Bran is made up of the outer layers of the wheat kernel. Bran is used in whole wheat flour. It is also used in breakfast cereals.



The germ is tiny - about 2 1/2% of the whole wheat kernel. The germ is the part that will sprout and grow into a new wheat plant if the kernel is planted. Wheat germ is sold in grocery stores and food markets. Whole wheat flour also contains wheat germ.

Malted barley is barley that has been allowed to germinate (sprout) to a degree and is then dried. This is accomplished industrially by increasing the water content of the seed to 40-45% by soaking it for a period close to 40 hours. The seed is then drained and held at a constant temperature (60 F) for close to 5 days until it starts to sprout. The barley is slowly dried in a kiln at temperatures gradually rising to 122 F for lighter malts and 220 F for darker malts. This kiln drying takes about 30 hours. Finally, the rootlets from the partially germinated seeds are removed.

iron, iron sulfate, Used in the food industry as a carrier for iron.



Iron in the body works with proteins that release energy in metabolism such as hemoglobin, which carries oxygen in the blood stream. Also involved in the making of ammino acids, hormones, and neurotransmitters.

Iron can be found in meats, poultry, and fish and many fortified foods. Fruits, vegetables and juices also provide some iron.

Iron deficiency symptoms include; anemia, inability to concentrate, weakness, fatigue, pallor, being out of breath after small exertion, cold hands and feet. Some people may develop a smooth round tongue, and have difficulty swallowing.



Symptoms of overload include: nausea, vomiting, diarrhea, rapid heartbeat, dizziness, shock and even death.



***Parents should be warned that iron supplements and multivitamins containing iron are the second most common cause of poisoning in young children in the U.S. (Aspirin is the first) The lethal dose of ferrous sulfate for a 2-year-old is only 3g.***



Source: Harvard Medical School - Health Publications Group, Vitamins and Minerals